Inside Line: Manbat

by

Introduced in 2008, the ‘BlueMotion’ version of VW’s ultra successful Golf incorporates the company’s Start-Stop system.

As these vehicles begin to drop out of the franchised dealer network and enter the independent sector, workshops, and the technicians undertaking service and repair work on these variants, need to bear in mind that they are not fitted with traditional lead-acid starter batteries. Instead these models use an AGM battery such as a Varta Start Stop Plus and will therefore require specialist knowledge and equipment to ensure the correct removal and installation process is followed.

In addition, as the battery in the system is integrated with the vehicle’s battery management system and its ECU, thorough diagnosis is required to discover whether the battery needs to be replaced or if there is an underlying cause that might have led to its premature failure.

Having the ability to cancel and reset the fault codes that may be required for associated components like the alternator and starter motor, as well as the Start-Stop system, means that workshops would be wise to invest in the necessary tooling and training to allow them to tackle these issues.

Manbat, the UK’s largest automotive battery distributor, is also the primary distributor for Varta Europe’s leading Start-Stop battery manufacturer. Together they have the products, equipment, and in association with eXponentia, the technical expertise, to ensure that workshops are fully prepared and have the confidence to service not only the VW Golf, but any other Start-Stop vehicle they may encounter.

ECP BOSS WARNS OF BLOCK EXEMPTION ‘EXISTENTIAL THREAT’

Andy Hamilton rails against VM ‘mini monopolies’ and demands that the UK government and the CMA take action in face of ‘abuse’ of the rules

Read More

PRA BOSS CALLS FOR FORECOURT ‘PINGDEMIC’ EXCLUSION

‘Forecourt workers are essential and should be exempt from self-isolation requirements if fully vaccinated’, say PRA

Read More

YORKSHIRE EXHAUST SPECIALISTS SAY ‘YES’ TO AAG BUYOUT

Leeds-based firm had been a UAN member and employed over 60 people

Read More

NEW TRADE COALITION FORMED TO FIGHT BLOCK EXEMPTION THREAT

AFCAR comprises of bosses from four major UK trade bodies

Read More

HALFORDS TO HIRE 700 TECHNICIANS

Chain hiring following a busy year for vehicle mobile servicing and pedal cycles

Read More

Go to comments

Your email address will not be published. Required fields are marked *